Product ID:TOLUENE-METHYL ISOBUTYL KETONE MIXTURE
MSDS Date:07/11/1986
FSC:6810
NIIN:00-286-2285
MSDS Number: BDTTJ

CSD INC.

5 HACKBERRY LANE
CONROE, TX 77305
US

Emergency Phone: 409-756-1065

Info Phone: 409-756-1065

Cage: JO933

CSD INC.

687 CONROE, TX 77305 US

Telephone: 409-756-1065

Cage: JO933

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 50%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL ISOBUTYL KETONE (SARA III)

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 50%

OSHA PEL 100 PPM/75 STEL

ACGIH TLV: 50 PPM/75 STEL; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:LD50 (ORAL RAT) IS 3540 MG/KG (MIX AVG.)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: VAPOR IRRITATES EYES, NOSE AND
THROAT; IS ANESTHETIC. LIQUID IS IRRITATING TO SKIN, CAUSING
DERMATITIS. CHRONIC: BRAIN CELL DAMAGE MAY RESULT FROM LONG TERM
INHALATION OF TOLUENE VAPOR. RESPIRA TORY TRACT IRRITATION.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE, SKIN & RESPIRATORY TRACT IRRITATION. MAY
CAUSE HEADACHE, NARCOSIS, COMA, DERMATITIS, MUSCLE FATIGUE,
WEAKNESS, DIZZINESS, NERVOUSNESS, PARESTHESIA, PHOTOPHOBIA, AND
CONFUSION.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:
REMOV E CONTAMINATED CLOTHING. WASH SKIN WITHSOAP & WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTIO

Flash Point Method:TCC
Flash Point:52F,11C
Lower Limits:1.4
Upper Limits:7.5
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:WATER MAY BE UNSUITABLE AS AN
EXTINGUISHING MEDIA, BUT HELPFUL IN KEEPING ADJACENT CONTAINERS
COOL. AVOID SPREADING BURNING LIQUID WITH WATER.

Spill Release Procedures:SMALL SPILL: WIPE/SOAK UP WITH PAPER TOWEL OR
INERT ABSORBANT. PUT IN DISPOSAL CONTAINER. LARGE SPILL: EVACUATE
AND VENTILATE AREA. ELIMINATE SOURCES OR IGNITION. STOP LEAK IF
POSSIBLE. DIKE TO RETAIN RUN OFF. VACUUM UP FREE LIQUID. FLUSH
RESIDUE.
Neutralizing Agent:NOT APPLICABLE.

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM IGNITION SOURCES. KEEP CONTAINERS CLOSED WHEN NOT IN
USE. PROTECT CONTAINER FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
LAUNDER CONTAMINATE D CLOTHING BEFORE REUSE.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED AIR-SUPPLIED MASK
AS PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND
NIOSH-RESPIRATOR SELECTION.
Ventilation:MECHANICAL (GENERAL): EXPLOSION-PROOF VENTILATION
EQUIPMENT. LOCAL EXHAUST: FACE VELOCITY 60 FPM IN CONFINED AREA.
Protective Gloves:NEOPRENE, NITRILE, OR VPC
Eye Protection:CHEMICAL SPLASH GOGGLES WITH FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS. DO NOT SMOKE IN WORK AREA. PSN FOR
THIS PRODUCT IS CHANGE 27 JUL 93 FROM PAINT RELATED MATERIAL TO
FLAMMABLE LIQUIDS, N.O.S. PER MANUFACTURER.

HCC:F2
Boiling Pt:=110.6C, 231.F
Vapor Pres:40
Vapor Density:3.45
Spec Gravity:0.836
Evaporation Rate & Reference:1.65(N-BUTYL ACETATE = 1)
Solubility in Water:MODERATE
Appearance and Odor:CLEAR, COLORLESS LIQUID, AROMATIC HYDROCARBON ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
CAUSTIC, AMINES, ALKANOLAMINES, AMMONIA, HALOGENS, ORGANIC & INORGANIC
ACIDS, STRONG OXIDIZERS & CHLORINATED COMPOUNDS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE

Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.